| 262 | 13 | 245 |
| 下载次数 | 被引频次 | 阅读次数 |
采用缺氧/好氧一体式膜生物反应器(A/O-MBR)对石化废水进行深度处理,经过60d左右的试验运行,结果表明系统处理效果理想。对COD、石油类物质和NH+4-N的平均去除率分别为91.9%、92.9%和95.4%,出水水质达到《城市污水再生利用,工业用水水质》中的相关标准(GB/T19923—2005);对部分工艺参数进行优化探究后,发现最佳水力停留时间(RHT)为8h,最佳回流比为300%~400%。通过扫描电子显微镜(SEM)和清水通量测定对膜污染进行了初步探究,结果表明微生物和有机物等在膜面形成凝胶层是造成系统膜污染的主要原因,最佳的化学清洗方案为0.1%NaOH+0.2%HCl,能使膜清水通量恢复率达90%以上。
Abstract：The petrochemical wastewater had been advanced treated for reuse by anoxic/oxic submerged membrane bioreactor(A/O-MBR).After about 60 dof operation,the test results showed that the treatment effect of the system was satisfactory.And the average removal rate of COD,oil and NH+4-N could reach 91.9%,92.9% and 95.4%,respectively.The system effluent indexes were superior to the water quality standard for industrial using in the reuse of urban recycling water(GB/T 19923-2005);The best hydraulic retention time(HRT)was 8hand the best reflux ratio was 300% ~400%.The membrane fouling had been studied by scanning electron microscope(SEM)and measuring of water flux.It was shown that the organic fouling and gel layer fouling contributed to the MBR membrane fouling,which contained organic matter and microorganism.The sequential 0.1% NaOH and 0.2% HCl chemical cleaning method was most effective,over 90% of the membrane permeability could be recovered.
[1]Siddique M N I,Sakinah Abd Munaim M,Zularisam A W.Mesophilic and thermophilic biomethane production by co-digesting pretreated petrochemical wastewater with beef and dairy cattle manure[J].Journal of Industrial and Engineering Chemistry,2014,20(1):331-337.
[2]胡保安,连立国,陈卓,等.MBR和UF深度处理石化废水的比较研究[J].中国给水排水,2006,22(15):80-82.
[3]Zheng X,Zhou Y,Chen S,et al.Survey of MBR market:trends and perspectives in China[J].Desalination,2010,250(2):609-612.
[4]Stephenson T,Judd S,Jefferson B,et al.Membrane Bioreactors for Wastewater Treatment[M].UK:IWA Publishing,Padstow,Cornwall,2001.
[5]黄霞,曹斌,文湘华,等.膜-生物反应器在我国的研究与应用新进展[J].环境科学学报,2008,28(3):416-432.
[6]Silvia Di Fabio,Simos Malamis,Evina Katsou,et al.Are centralized MBRs coping with the current transition of large petrochemical areas?A pilot study in Porto-Marghera(Venice)[J].Chemical Engineering Journal,2013,214:68-77.
[7]Viero A F,ThaináM,de Melo,et al,The effects of long-term feeding of high organic loading in a submerged membrane bioreactor treating oil refinery wastewater[J].Journal of Membrane Science,2008,319(1-2):223-230.
[8]Jian-Jun Qin,Maung Htun Oo,Guihe Tao,et al.Feasibility study on petrochemical wastewater treatment and reuse using submerged MBR[J].Journal of Membrane Science,2007,293:161-166.
[9]李玲.MBR在石化企业污水处理上的可行性探讨[J].石油化工安全环保技术,2012,28(1):53-64.
[10]李勇,钟捷.石化废水处理中MBR工艺的运行管理[J].工业水处理,2011,31(12):81-84.
[11]国家环境保护总局.水和废水监测分析方法[M].第四版.北京:中国环境科学出版社,2002.
[12]孟壮,黄星,郝华伟,等.MIBR-纳滤组合工艺在生活污水回用中的应用研究[J].水处理技术,2013,39(10):89-92.
[13]Fallah N,Bonakdarpour B,Nasernejad B,et al.Long-term operation of submerged membrane bioreactor(MBR)for the treatment of synthetic wastewater containing styrene as volatile organic compound(VOC)Effect of hydraulic retention time(HRT)[J].Journal of Hazardous Materials,2010,178:718-724.
[14]杜传华,赵帆,林少华,等.A/O-MBR处理生活污水影响因素研究[J].广东化工,2013,40(21):139-141.
[15]GB 8978-1996,污水综合排放标准[S].北京:中国环境科学出版社,1996.
[16]GB/T 19923-2005,城市污水再生利用工业用水水质[S].北京:中国标准出版社,2006.
[17]郭亚辉.A1/A2/O-膜生物反应器-纳滤组合工艺深度处理焦化废水的研究[D].青岛:中国海洋大学,2013.
[18]孙赛玉.MBR膜污染层胞外多糖性质分析,污染特征及膜污染防治研究[D].无锡:江南大学,2008.
基本信息:
DOI：10.16441/j.cnki.hdxb.20140159
中图分类号:X742
引用信息:
[1]郑云,洪海云,张星星,等.A/O-MBR在石化废水深度处理回用中的应用[J],2015,45(08):76-82.DOI:10.16441/j.cnki.hdxb.20140159.
基金信息:
高通量纳滤膜材料的规模化制备技术项目(2012AA03A602);; 工业污水处理稳定、高效、节能关键技术与污泥量同步削减关键技术装备开发与工程示范项目(2012CX70301);; MBR-NF处理世园会园区污水回用技术项目(12-1-3-56-nsh)资助